Kimberly‑Clark Halyard Stay‑Dry Ice Pack: 2025 Guide

Updated September 2025. The Kimberly‑Clark Halyard Stay‑Dry Ice Pack delivers long, stable cold with minimal condensation, built‑in ties, and fast clip closure. You get up to ~2.5 hours of cold readiness, while skin application stays within safe 10–15‑minute cycles. This guide shows you how to size, prep, apply, clean, and store it—and how to standardize across departments to reduce leaks, wet floors, and rework. Specs and sizing are consolidated from manufacturer literature and internal operational drafts.

Sizing choices for targeted cold therapy (long‑tail: ice pack size guide for knees and cheeks)
Safe timing and skin protection (long‑tail: how long to use an ice pack after surgery)
Prep, cleaning, and dispensing SOPs (long‑tail: ice machine hygiene checklist for clinics)
Department‑specific use cases and trends (long‑tail: ER and PACU cold therapy workflow)

Which size of Kimberly‑Clark Halyard Stay‑Dry Ice Pack should you choose?

Direct answer: Use the 5″×12″ for cheeks, wrists, ankles, and pedi sites; use the 6.5″×14″ for knees, shoulders, and thighs. The larger bag covers more surface area and warms slower; the smaller bag contours better on facial or distal areas. Both versions share the three‑layer Stay‑Dry construction, clip closure, and four ties for hands‑free positioning.

Why it matters: A good fit keeps cold where you need it without babysitting the pack. You’ll get consistent cooling and drier linens, especially when the Kimberly‑Clark Halyard Stay‑Dry Ice Pack is secured over moving joints. In ambulatory settings, ties prevent slipping, and a wall‑mounted dispenser near the ice machine speeds prep. Stock both sizes so staff can match anatomy and motion. Codes commonly used: small 33495; large 33500.

Stay‑Dry design vs. standard ice bags

Details: The three‑layer build—soft outer comfort layer, absorbent middle layer, and leak‑resistant inner film—keeps the exterior drier than single‑layer bags. You avoid towel‑wrapping for condensation and cut housekeeping calls. In practice, the Kimberly‑Clark Halyard Stay‑Dry Ice Pack stays put with ties, while the clip closure makes refills fast. That combination reduces time at the ice machine and improves patient comfort across shifts.

Size & Use Map	Typical Areas	Tie Setup	What it means for you
5″×12″ (33495)	Cheek/mandible, wrist, ankle	2 ties or simple wrap	Contoured fit, less bulk, precise cooling
6.5″×14″ (33500)	Knee, shoulder, thigh	4 ties cross‑secured	Broad coverage, slower heat gain, fewer refills
Ambulatory use	Mobile patients	Moderate tension, quick recheck	Hands‑free icing during movement

Practical tips & suggestions

Post‑op knee: Use the large Kimberly‑Clark Halyard Stay‑Dry Ice Pack with four ties for steady contact while ambulating.
Dental/maxillofacial: Choose the small bag; check skin every 10–15 minutes.
OB/perineal: Use specialty packs where indicated; the small bag can bridge gaps with proper draping and time limits.

Real‑world case: A day‑surgery unit mounted the Stay‑Dry dispenser by the ice machine and standardized prep steps. Setup time dropped from ~3 minutes to <1 minute per bag, with fewer wet‑floor reports during peak hours.

How long should you apply the Kimberly‑Clark Halyard Stay‑Dry Ice Pack safely?

Direct answer: Keep skin applications to 10–15 minutes (max ~20) per session with a thin fabric barrier. The bag can remain cold for ~2.5 hours off the machine, but skin contact windows should stay short to avoid cold‑induced injury. Pause if numbness or color changes occur.

Explanation: Cold readiness ≠ safe skin time. Think of the Kimberly‑Clark Halyard Stay‑Dry Ice Pack as a reservoir: it stays cold on the bench, while your skin needs shorter cycles. Most guidance favors 10–15‑minute sessions, repeated several times a day for the first 24–48 hours after injury or surgery. For neuropathy, vascular disease, or fragile skin, shorten contact and increase checks. Always keep a dry cloth between skin and the pack.

A simple skin‑safety routine

Details: Barrier → Timer → Check. Place a thin cloth, set 10–15 minutes, inspect color and sensation, then rotate sites. This routine protects tissue while maintaining therapeutic cold. Use smaller windows on thin skin (e.g., wrists) and review comfort after each cycle when using the Kimberly‑Clark Halyard Stay‑Dry Ice Pack.

Common Scenario	Typical Session	Max per Session	What it means for you
Acute sprain/strain	10–15 min	≤20 min	Short cycles more often in first 48 h
Arthritis flare	10–15 min	≤20 min	Cold to blunt pain; reassess stiffness
Sensitive areas	5–10 min	≤15 min	Extra caution on small joints/thin skin

Practical tips & suggestions

Check midway: Inspect once during each application; stop if gray/blue discoloration or sharp numbness appears.
Barrier cloth: Always use a thin, dry layer between skin and the Kimberly‑Clark Halyard Stay‑Dry Ice Pack.
Timer discipline: Use a visible timer; repeat as prescribed, not continuously.

Actual case: A sports clinic cut post‑treatment skin complaints to near zero after adopting 10–15‑minute timers with barrier cloth across all icing stations.

How do you prep, clean, and store the Kimberly‑Clark Halyard Stay‑Dry Ice Pack?

Direct answer: Open the clip, fill with crushed ice to ~⅔, expel air, clamp, apply with ties, then clean the exterior with a compatible hospital‑grade disinfectant per label dwell time. Treat as a noncritical item; dry fully before storage.

Explanation: A dispenser mounted beside the ice machine shortens travel time and reduces handling. Pair this with a written ice‑machine hygiene plan and SOP cards at the station. The Kimberly‑Clark Halyard Stay‑Dry Ice Pack supports fast refills and hands‑free use, enabling a consistent, disposable‑friendly workflow in ER, OR/PACU, dental, and OB settings.

Clinic‑ready workflow

Details: Standardize steps so new staff can execute safely under pressure. Use crushed ice, avoid over‑tight ties, and log machine cleans quarterly. These habits protect patients and keep floors dry—two quick wins that improve patient experience and safety metrics.

Storage & Dispensing	Minimum Standard	Better Practice	What it means for you
Location	Within 10 m of use area	Mounted beside ice machine	Faster access, fewer steps
Handling	Scoop; no hand contact	Touchless drop to container	Lower contamination risk
Cleaning	Monthly	Per maker + quarterly deep clean	Stable ice quality, fewer outages

Practical tips & suggestions

Mount the dispenser: Keep Kimberly‑Clark Halyard Stay‑Dry Ice Pack cartons within arm’s reach of the ice machine.
Fill smart: Use crushed ice; fill to 50–70%; expel air for better conformity.
Disinfect correctly: Follow label dwell times; dry fully before storage.

Actual case: After adding a laminated mini‑SOP at the ice station, one OR reported consistent fill quality and fewer interruptions for troubleshooting during peak turnover.

Is the Kimberly‑Clark Halyard Stay‑Dry Ice Pack right for your department?

Direct answer: Yes—if you need fast, dry, secure cold therapy. ER sprains, PACU/OR post‑op cooling, dental/maxillofacial swelling, and selected OB comfort needs all benefit. For stationary, extra‑long cold, complement with specialty packs as your protocol allows.

Explanation: The four ties and clip closure make the Kimberly‑Clark Halyard Stay‑Dry Ice Pack easy to standardize across services. Dental suites prefer the small size for cheek contouring; ORs cut set‑up time with a hanging dispenser; ERs need quick, secure cooling for sprains and strains.

Ties vs. hook‑and‑loop (quick selection matrix)

Details: Ties offer flexible placement and conforming pressure; hook‑and‑loop straps (if available) speed refits. Choose based on anatomy, motion, and staffing.

Use Case	Ties	Hook‑and‑Loop	Takeaway
Post‑op knee	✓✓✓	✓✓	Ties allow cross‑secure around a joint
Facial/dental	✓✓	—	Smaller bag + ties contour best
Ambulatory	✓✓✓	✓✓	Hands‑free during movement

2025 cold‑therapy developments and trends

Trend overview: Facilities emphasize biofilm‑aware ice‑machine hygiene, latexfree/DEHP‑free patient‑contact materials, and streamlined ownership under the HALYARD brand (now within Owens & Minor). These trends favor dry‑surface solutions such as the Kimberly‑Clark Halyard Stay‑Dry Ice Pack, which delivers comfort while reducing wet linens and slip risks. Procurement teams increasingly standardize around a single brand family to simplify training and stocking.

At a glance

Infection‑control focus: Routine cleaning and touchless dispensing reduce contamination from ice handling.
Material safety: Not made with natural rubber latex or DEHP aligns with allergy‑aware policies.
Workflow wins: Dispensers cut seconds per prep that compound over shifts, boosting throughput.

Market insight: Organizations formalize written maintenance strategies for ice machines and adopt drier cold therapy to reduce housekeeping load and near‑miss incidents. Staff compliance improves when the Kimberly‑Clark Halyard Stay‑Dry Ice Pack is part of a visible, easy station layout with timers and barrier cloths at arm’s reach.

Frequently asked questions

Q1: How long does a Kimberly‑Clark Halyard Stay‑Dry Ice Pack stay cold?
Up to ~2.5 hours of cold readiness; keep skin sessions to 10–15 minutes with a barrier cloth.

Q2: Is it latex‑ and DEHP‑free?
Yes. Manufacturer literature specifies no natural rubber latex or DEHP for these ice packs.

Q3: What sizes should I stock?
Small 5″×12″ (33495) and large 6.5″×14″ (33500) cover most needs; both use clip closure and ties.

Q4: Can it be sterilized?
No. Treat as a noncritical item. Clean the exterior with a compatible disinfectant and let it dry.

Q5: Is it suitable for cold‑chain shipping?
No. It’s a patient cold‑therapy product, not a validated passive shipper for temperature‑sensitive goods.

Summary & recommendations

Key points: The Kimberly‑Clark Halyard Stay‑Dry Ice Pack offers long, dry cold, fast clip closure, and secure ties. Stock two sizes, mount a dispenser by the ice machine, and keep skin applications to 10–15 minutes with a barrier. Build timers and cleaning into your SOP to reduce wet‑floor incidents and rework.

Next steps:

Standardize size by department and document a one‑page SOP.
Install a hanging dispenser; place timers and barrier cloths at the station.
Audit ice‑machine hygiene quarterly; train on skin‑safety checks.
CTA: Need a turnkey SOP, training sheet, and station layout? Contact Tempk for an implementation kit.

About Tempk

We help hospitals and clinics standardize cold‑therapy workflows—from point‑of‑use icing to freezer monitoring and staff SOPs. Our practical playbooks, validation templates, and onboarding workshops reduce setup time and improve compliance. With the Kimberly‑Clark Halyard Stay‑Dry Ice Pack program, we make care consistent across shifts with fewer leaks and faster prep. Talk to a Tempk specialist for a 30‑minute workflow tune‑up.